Gastonia Roof Pros provides professional flat & low-slope roofing in Gastonia, NC for residential and commercial properties across Gaston County and the western Charlotte metro. Most low-slope roofing we do here happens on houses, not on commercial buildings, and it sits at the back: a kitchen added in 1955, a bathroom added in 1962, a porch enclosed sometime after that, each one a shallow shed tied into the original roof.
Nearly all of them are shingled, and nearly all of them should not be. Asphalt shingles are not rated below a 2:12 pitch, and a great many of these additions sit at 1:12 or flatter. It was done that way because shingles were what the crew had on the truck, and it worked for a while because the slope drained fast enough to hide the mistake.
What fails is the transition, not the field. Water running off the main roof hits the low plane at speed, backs up under the top course, and travels along the board decking until it finds a gap. By the time the ceiling stains, the top plate and the ends of several boards are already gone. By then it is a framing repair with a roofing repair sitting on top of it.
The fix on a small residential plane is self-adhered modified bitumen. A base sheet and a granulated cap, torch-free, carried at least eight inches up the wall and tucked behind counterflashing rather than under a bead of sealant. On a plane under three squares, it is a one-day job and costs less than most people expect. Small planes, low cost, and a very large share of this city's ceiling stains.
Where the plane is bigger or a future addition is likely, we will use a mechanically attached TPO or an EPDM sheet over a half-inch cover board instead, with the seams heat-welded or seam-taped and the perimeter fastened on a real schedule. That gets you a proper drain edge and a membrane that takes foot traffic. On anything a service technician will walk, that extra rigidity pays for itself.
One thing we insist on either way is a positive slope to somewhere. If the deck ponds, we build a tapered insulation cricket or re-frame the plane rather than putting a good membrane over a bathtub and calling it done. Standing water is what turns a twenty-year roof into an eight-year roof. Water that cannot leave a roof will eventually find its way into the building.
Our licensed and insured team brings the right materials and equipment to every job — rough-sawn 1x6 and 1x8 board decking, true-dimension 2x4 rafters at 24 inches on center, three-eighths plywood overlay across board sheathing, wood shingle lath buried under two layers of asphalt, abandoned central brick stove flues, slotted eave intake vents cut through the deck — and backs the work with a written workmanship warranty. We serve Gastonia and nearby communities including Belmont, Mount Holly, Bessemer City, Dallas.
What We Handle
Everything our flat & low-slope roofing in Gastonia covers
One crew, one point of contact, and the full range of flat & low-slope roofing work in Gastonia, NC. If it is on this list we do it in house rather than handing it to a subcontractor:
- flat roof repair gastonia
- low slope roof addition
- modified bitumen roof nc
- tpo roof residential
- porch roof low slope
- shed roof shingles code
- self adhered membrane roof
- epdm rubber roof gastonia
- flat roof leak repair
- kitchen addition roof
- low slope roofing contractor gaston county
Not sure which one describes your situation? Describe it in plain words and we will sort it out — or browse the rest of our Gastonia services.
Materials, equipment and how we do flat & low-slope roofing
The difference between flat & low-slope roofing that lasts and flat & low-slope roofing that gets redone in three years is almost always preparation and materials, not the finish you see on day one. We work with rough-sawn 1x6 and 1x8 board decking, true-dimension 2x4 rafters at 24 inches on center, three-eighths plywood overlay across board sheathing, wood shingle lath buried under two layers of asphalt, spec them to the job instead of to the invoice, and write the material grades into the free estimate so you know exactly what you are buying.
Every Gastonia job runs the same way: site walk and measurements, written scope and fixed price, protection of the surrounding area, then the work itself with a daily clean-up. Years of roofing work in Gaston County and the western Charlotte metro means we have already met whatever your property is going to throw at us — awkward access, older construction, an HOA with opinions.
Where we do flat & low-slope roofing outside Gastonia
Gastonia Roof Pros covers Gastonia and the surrounding communities of Gaston County and the western Charlotte metro. Crews run out to the same nearby cities every week, so an out-of-town job does not mean an out-of-town price.
- Flat & Low-Slope Roofing in Belmont, NC — Gaston County, population 15,010
- Flat & Low-Slope Roofing in Mount Holly, NC — Gaston County, population 17,703
- Flat & Low-Slope Roofing in Bessemer City, NC — Gaston County, population 5,428
- Flat & Low-Slope Roofing in Dallas, NC — Gaston County, population 5,927
- Flat & Low-Slope Roofing in Lowell, NC — Gaston County, population 3,654
- Flat & Low-Slope Roofing in Cramerton, NC — Gaston County, population 5,296
Start on the Gastonia Roof Pros homepage for a free estimate, or call (844) 511-2320 and describe the job.
Why Gastonia Chooses Gastonia Roof Pros
- ✓We date your roof by its building campaign, not by a guess. Layer count, board width, rafter dimension and flue condition, because on cohort-built housing those four readings predict the job.
- ✓A plane comes open before the price is final. On a board deck the fastener gaps and the soft board ends are the entire risk, and photographing them beats absorbing them later as a change order.
- ✓Decking is a separate line item with a per-board and a per-sheet rate written down, so a re-deck is a number you agreed to rather than a surprise delivered from the ladder.
- ✓We refuse work that the framing cannot carry. Tile on true-dimension rafters, coatings over shingles, and impact-rated upgrades on a roof already carrying two layers all get a no and a reason.
The standards behind flat & low-slope roofing
Quality here is not a matter of opinion — it is written down. The flat & low-slope roofing work we do in Gastonia follows published industry standards: NRCA publishes the Roofing Manual, the industry's reference for details and slope minimums, and Asphalt Roofing Manufacturers Association sets the shingle application and ventilation guidance the warranties reference. If a contractor cannot tell you which standard a detail comes from, that is worth asking about before you sign.
Every flat & low-slope roofing project in Gastonia gets the same attention, whether it is a single room or a full commercial job. We show up on schedule, keep the site clean, and stand behind the work — the estimate is free and there is no pressure.
Ready to get started? Call (844) 511-2320 for a free flat & low-slope roofing free estimate in Gastonia, or request a quote and we'll get right back to you.